• الصفحة الرئيسية
  • بررسی تجربی تأثیر استفاده از پره بر روی لوله آتشدان گرم‌کن ایستگاه تقلیل فشار گاز طبیعی بر راندمان حرارتی و کاهش انتشارگازهای گلخانه‌ای

شارک

عنوان URL للمقالة


رقم المقالة : JEST-2003-5041 (R1) زيارة : 112 الصفحة: 181 - 193

10.22034/jest.2020.51771.5041

نوع المخطوط: ابحاث

بررسی تجربی تأثیر استفاده از پره بر روی لوله آتشدان گرم‌کن ایستگاه تقلیل فشار گاز طبیعی بر راندمان حرارتی و کاهش انتشارگازهای گلخانه‌ای

الموضوعات :

سعید رستگار 1 (دانشجوی دکترا، گروه مهندسی مکانیک، واحد سمنان، دانشگاه آزاد اسلامی، سمنان، ایران.)
هادی کارگر شریف آباد 2 (دانشیار، مرکز تحقیقات انرژی و توسعه پایدار، واحد سمنان، دانشگاه آزاد اسلامی، سمنان، ایران. *(مسوول مکاتبات))
نادر رهبر 3 (استادیار، مرکز تحقیقات انرژی و توسعه پایدار، واحد سمنان، دانشگاه آزاد اسلامی، سمنان، ایران.)
محمد بهشاد شفیعی 4 (استاد، دانشکده مهندسی مکانیک، دانشگاه صنعتی شریف، تهران، ایران.)

تاريخ الإرسال : 27 الأحد , رجب, 1441 تاريخ التأكيد : 03 الثلاثاء , شوال, 1441 تاريخ الإصدار : 20 الخميس , رمضان, 1443

الکلمات المفتاحية: گازهای گلخانه‌ای, گرم‌کن, راندمان گرمائی, ایستگاه تقلیل فشار گاز طبیعی,

ملخص المقالة :

زمینه و هدف: فشار گاز طبیعی در ایستگاه تقلیل فشار به‌وسیله رگولاتور کم می‌شود و طبق قانون عمومی گازها، با کاهش در حجم ثابت، دمای گاز نیز کاهش می‌یابد. اگر دمای گاز به پایین‌تر از دمای نقطه شبنم برسد، سبب تشکیل هیدرات، یخ زدگی و درنهایت انسداد و گرفتگی مسیر عبور گاز می‌گردد. از این رو از گرم‌کن غیرمستقیم حمام آب گرم جهت افزایش دمای گاز قبل از تقلیل فشار استفاده می‌شود. در حال حاضر راندمان حرارتی این گرم‌کن‌ها بسیار پایین بوده و مقدار وسیعی از سوخت در گرم‌کن تلف می گردد. روش بررسی: در این مقاله، تأثیر استفاده از پره در لوله آتشدان گرم‌کن ایستگاه تقلیل فشار گاز طبیعی بر راندمان حرارتی آن و کاهش گازهای گلخانه ای به‌صورت تجربی بررسی شده است و مشخصات ترمودینامیکی و انتقال حرارتی گرم‌کن در حالت معمولی و در حالت با پره با یکدیگر مقایسه شده است. یافته‌ها: نتایج نشان داد به‌کارگیری پره حرارتی بر روی لوله آتشدان گرم‌کن سبب می‌گردد راندمان حرارتی گرم‌کن و ضریب انتقال حرارتی جابجایی به ترتیب 14 و 19 درصد افزایش یابد. بحث و نتیجه‌گیری: اگر نتایج افزایش راندمان به کلیه گرم‌کن‌های ایستگاه تقلیل فشار گاز کشور تعمیم داده شود، میزان کاهش مصرف انرژی و کاهش انتشار گازهای گلخانه‌ای در طی یک سال به ترتیب 40 میلیون مترمکعب و 75/76 هزار تن برآورد گردیده است.

المصادر:


  1. Olfati, M. Bahiraei, S. Heidari, and F. Veysi, “A comprehensive analysis of energy and exergy characteristics for a natural gas city gate station considering seasonal variations”, Energy, pp. 721–733, 2018.
    2.
  2. Olfati, M. Bahiraei, and F. Veysi, “A novel modification on preheating process of natural gas in pressure reduction stations to improve energy consumption, exergy destruction and CO2 emission: Preheating based on real demand”, Energy, vol. 173, pp. 598–609, 2019.
    3.
  3. Rastegar, H. Kargarsharifabad, M. B. Shafii, and N. Rahbar, “Experimental investigation of the increasing thermal efficiency of an indirect water bath heater by use of thermosyphon heat pipe”, Thermal Science, vol. OnLine-Fir, 2020.
    4.
  4. H. Azizi et al., “Study of preheating natural gas in gas pressure reduction station by the flue gas of indirect water bath heater”, Research at Islamic Azad University, Bandar Lengeh branch, Iran, vol. 3, no. 27, pp. 17–22, 2014. (In Persian)
    5.
  5. Rastegar, H. Kargarsharifabad, N. Rahbar, M.B. Shafii, “Distilled water production with combination of solar still and thermosyphon heat pipe heat exchanger coupled with indirect water bath heater - experimental study and thermoeconomic analysis”, Applied Thermal Engineering, First Online, 2020.
    6.
  6. Khalili, M. Hoseinalipour, and E. Heybatian, “Efficiency and heat losses of indirect water bath heater installed in natural gas pressure reduction station; evaluating a case study in Iran”, in Proceedings of 8th National Energy Congress, Shahrekord, Iran, 2011. (In Persian)
    7.
  7. Farzaneh-Gord and M. Deymi-Dashtebayaz, “Recoverable Energy in Natural Gas Pressure Drop Stations: A Case Study of the Khangiran Gas Refinery”, Energy Exploration & Exploitation, vol. 26, no. 2, pp. 71–82, 2008.
    8.
  8. Zabihi and M. Taghizadeh, “Feasibility study on energy recovery at Sari-Akand city gate station using turboexpander”, Journal of Natural Gas Science and Engineering, vol. 35. pp. 152–159, 2016.
    9.
  9. Riahi, B. Yazdirad, M. Jadidi, and F. Berenjkar, “Optimization of Combustion Efficiency in Indirect Water Bath Heaters of Ardabil City Gate Stations”, Seventh Mediterranean Combustion Symposium, 2011.
    10.
  10. J. Kostowski and S. Usón, “Comparative evaluation of a natural gas expansion plant integrated with an IC engine and an organic Rankine cycle”, Energy Conversion and Management, vol. 75, pp. 509–516, 2013.
    11.
  11. Naderi, G. Ahmadi, M. Zarringhalam, O. Akbari, and E. Khalili, “Application of water reheating system for waste heat recovery in NG pressure reduction stations, with experimental verification”, Energy, vol. 162, pp. 1183–1192, 2018.
    12.
  12. Farzaneh-Gord, S. Izadi, M. Deymi-Dashtebayaz, S. I. Pishbin, and H. Sheikhani, “Optimizing natural gas reciprocating expansion engines for Town Border pressure reduction stations based on AGA8 equation of state”, Journal of Natural Gas Science and Engineering, vol. 26, pp. 6–17, 2015.
    13.
  13. Kargaran, A. Arabkoohsar, S. J. Hagighat-Hosini, V. Farzaneh-Kord, and M. Farzaneh-Gord, “The second law analysis of natural gas behaviour within a vortex tube”, Thermal Science, vol. 17, no. 4, pp. 1079–1092, 2013.
    14.
  14. ghasemikafrudi, M. Amini, M. R Habibi and F Goodarzvand, “Evaluation of Greenhouse Gas Emissions of Gas Pressure Reduction Stations”, Journal of Environmental Science and Technology, First Online, 2018. (In Persian)
    15.
  15. Marandi, M.E. masomi, H. Azad manesh, “Investigating the Effects of Energy Optimization Methods on Gaseous Pollutant Emissions”, Journal of Environmental Science and Technology, vol. 8, pp. 95–108, 2007. (In Persian)
    16.
  16. W. Zemansky, M. M. Abbott, and H. C. Van Ness, Basic engineering thermodynamics. McGraw-Hill Companies, 1975.
    17.
  17. U. Schlunder, “Heat exchanger design handbook”, 1983.
    18.
  18. Incropera and D. DeWitt, “Introduction to heat transfer”, 1985.
    19.
  19. E. I. 14064-1, Greenhouse gases, Part 1: Specification with guidance at the organization level for quantification and reporting of greenhouse gas emissions and removals. 2012.
    20.
  20. Greenhouse Gas Emissions., Unofficial electronic version of the Regulation for the Mandatory Reporting of Greenhouse Gas Emissions. Http://www.oal.ca.gov/CCR.htm.
    21.
  21. A. Bell, “A beginner’s guide to uncertainty of measurement.”, 2001.
    22.
  22. A. MCCLINTOCK, “Describing uncertainties in single-sample experiments”, Mechanical Engineering, vol. 75, no. 1, pp. 3–8, 1953.
    23.
  23. Rastegar, “Experimental Investigation of Using Heat Pipe for Increase Efficiency of  Indirect Water Bath Heater” , Ph.D Thesis, Islamic azad university, semnan beranch, 2020. (In Persian)
    24.
  24. “www.nigc.ir”, (In Persian)
    25.

 

 

 

 

_||_

  1. Olfati, M. Bahiraei, S. Heidari, and F. Veysi, “A comprehensive analysis of energy and exergy characteristics for a natural gas city gate station considering seasonal variations”, Energy, pp. 721–733, 2018.
    2.
  2. Olfati, M. Bahiraei, and F. Veysi, “A novel modification on preheating process of natural gas in pressure reduction stations to improve energy consumption, exergy destruction and CO2 emission: Preheating based on real demand”, Energy, vol. 173, pp. 598–609, 2019.
    3.
  3. Rastegar, H. Kargarsharifabad, M. B. Shafii, and N. Rahbar, “Experimental investigation of the increasing thermal efficiency of an indirect water bath heater by use of thermosyphon heat pipe”, Thermal Science, vol. OnLine-Fir, 2020.
    4.
  4. H. Azizi et al., “Study of preheating natural gas in gas pressure reduction station by the flue gas of indirect water bath heater”, Research at Islamic Azad University, Bandar Lengeh branch, Iran, vol. 3, no. 27, pp. 17–22, 2014. (In Persian)
    5.
  5. Rastegar, H. Kargarsharifabad, N. Rahbar, M.B. Shafii, “Distilled water production with combination of solar still and thermosyphon heat pipe heat exchanger coupled with indirect water bath heater - experimental study and thermoeconomic analysis”, Applied Thermal Engineering, First Online, 2020.
    6.
  6. Khalili, M. Hoseinalipour, and E. Heybatian, “Efficiency and heat losses of indirect water bath heater installed in natural gas pressure reduction station; evaluating a case study in Iran”, in Proceedings of 8th National Energy Congress, Shahrekord, Iran, 2011. (In Persian)
    7.
  7. Farzaneh-Gord and M. Deymi-Dashtebayaz, “Recoverable Energy in Natural Gas Pressure Drop Stations: A Case Study of the Khangiran Gas Refinery”, Energy Exploration & Exploitation, vol. 26, no. 2, pp. 71–82, 2008.
    8.
  8. Zabihi and M. Taghizadeh, “Feasibility study on energy recovery at Sari-Akand city gate station using turboexpander”, Journal of Natural Gas Science and Engineering, vol. 35. pp. 152–159, 2016.
    9.
  9. Riahi, B. Yazdirad, M. Jadidi, and F. Berenjkar, “Optimization of Combustion Efficiency in Indirect Water Bath Heaters of Ardabil City Gate Stations”, Seventh Mediterranean Combustion Symposium, 2011.
    10.
  10. J. Kostowski and S. Usón, “Comparative evaluation of a natural gas expansion plant integrated with an IC engine and an organic Rankine cycle”, Energy Conversion and Management, vol. 75, pp. 509–516, 2013.
    11.
  11. Naderi, G. Ahmadi, M. Zarringhalam, O. Akbari, and E. Khalili, “Application of water reheating system for waste heat recovery in NG pressure reduction stations, with experimental verification”, Energy, vol. 162, pp. 1183–1192, 2018.
    12.
  12. Farzaneh-Gord, S. Izadi, M. Deymi-Dashtebayaz, S. I. Pishbin, and H. Sheikhani, “Optimizing natural gas reciprocating expansion engines for Town Border pressure reduction stations based on AGA8 equation of state”, Journal of Natural Gas Science and Engineering, vol. 26, pp. 6–17, 2015.
    13.
  13. Kargaran, A. Arabkoohsar, S. J. Hagighat-Hosini, V. Farzaneh-Kord, and M. Farzaneh-Gord, “The second law analysis of natural gas behaviour within a vortex tube”, Thermal Science, vol. 17, no. 4, pp. 1079–1092, 2013.
    14.
  14. ghasemikafrudi, M. Amini, M. R Habibi and F Goodarzvand, “Evaluation of Greenhouse Gas Emissions of Gas Pressure Reduction Stations”, Journal of Environmental Science and Technology, First Online, 2018. (In Persian)
    15.
  15. Marandi, M.E. masomi, H. Azad manesh, “Investigating the Effects of Energy Optimization Methods on Gaseous Pollutant Emissions”, Journal of Environmental Science and Technology, vol. 8, pp. 95–108, 2007. (In Persian)
    16.
  16. W. Zemansky, M. M. Abbott, and H. C. Van Ness, Basic engineering thermodynamics. McGraw-Hill Companies, 1975.
    17.
  17. U. Schlunder, “Heat exchanger design handbook”, 1983.
    18.
  18. Incropera and D. DeWitt, “Introduction to heat transfer”, 1985.
    19.
  19. E. I. 14064-1, Greenhouse gases, Part 1: Specification with guidance at the organization level for quantification and reporting of greenhouse gas emissions and removals. 2012.
    20.
  20. Greenhouse Gas Emissions., Unofficial electronic version of the Regulation for the Mandatory Reporting of Greenhouse Gas Emissions. Http://www.oal.ca.gov/CCR.htm.
    21.
  21. A. Bell, “A beginner’s guide to uncertainty of measurement.”, 2001.
    22.
  22. A. MCCLINTOCK, “Describing uncertainties in single-sample experiments”, Mechanical Engineering, vol. 75, no. 1, pp. 3–8, 1953.
    23.
  23. Rastegar, “Experimental Investigation of Using Heat Pipe for Increase Efficiency of  Indirect Water Bath Heater” , Ph.D Thesis, Islamic azad university, semnan beranch, 2020. (In Persian)
    24.
  24. “www.nigc.ir”, (In Persian)
    25.

 

 

 

 

سند

Sanad is a platform for managing Azad University publications

الروابط

المراكز ذات الصلة

دعامة

الصفحات الرسمية

حقوق هذا الموقع الإلكتروني مملوكة لنظام SANAD Press Management. © 1442-1446

الصفحة الرئيسية| دخول| معلومات عنا| اتصل بنا|
[English] [فارسی] [en] [fa]