Experimental Study and Comparison of a Few Lean (gasoline-natural gas) Dual ‎F‎uels Based on Safe Optimum Spark Advance

الموضوعات : مجله بین المللی ریاضیات صنعتی

S. K. Yekani ¹ , E. Abdi ‎Aghdam‎ ² , M. Sarabi ³

1 - Department of Mechanical Engineering, Faculty of Engineering, University of Mohaghegh Ardabili, Ardabil, Iran.
2 - Department of Mechanical Engineering, Faculty of Engineering, University of Mohaghegh Ardabili, Ardabil, Iran.
3 - Department of Mechanical Engineering, Faculty of Engineering, University of Mohaghegh Ardabili, Ardabil, Iran.

تاريخ الإرسال : 03 الثلاثاء , جمادى الثانية, 1441 تاريخ التأكيد : 03 الثلاثاء , جمادى الثانية, 1441 تاريخ الإصدار : 02 الجمعة , ذو الحجة, 1443

الکلمات المفتاحية: Lean-‎burn‎, Dual fuel SI engine, Gasoline, Optimum Spark Advance, Emissions, Natural gas,

ملخص المقالة :

Strong dependence of the human’s daily life on the engine-powered vehicles, increasing environmental pollutions, especially in urban areas, and reduction of the world oil resources have challenged the energy researchers to make appropriate decisions at regional scale for selecting alternative fuels to improve the engine efficiency and fuel economy. In the current work, the lean-burn idea jointed to dual (gasoline-NG) fuel has been considered to develop the SI engines. To investigate the performance and exhaust gas emissions, experimental tests were performed using a single-cylinder research engine with gasoline-NG dual fuels, including four mass-based blends of the two fuels (G100, G87.5, G75, and G62.5 containing gasoline at 100‎\‎%, 87.5\%, 75\%, and 62.5\%, respectively, with the remaining part being composed of NG), at 1800 rpm ES and 0.9 ER under at least seven different SAs. The result showed that increasing the NG fraction in the fuel blend, both the σ and COV of imep decreased. It was implicitly observed that, for blended fuels, non-uniform distribution of each fuel can serve as a new source for cyclic variations. Under the considered lean burning condition at optimal safe SA, the imep and output torque for the gas-contained fuel blends were comparable to those obtained by the pure gasoline. Also, it was detected that an increase in the CR reduced the emitted amounts of HC and CO ‎pollutants.‎

المصادر:

 [1] A. H. Kakaee, A. Paykani, Research and development of natural-gas fueled engines in Iran, Renewable and Sustainable Energy Reviews 26 (2013) 805-821.
[2] B. Petroleom, BP Statistical Review of 

[3] H. M. Cho, H. Bang-Quan, Spark ignition natural gas engines a review, Energy Convers Manage 48 (2007) 608-618.
[4] M. I. Jahirul, H. H. Masjuki, R. Saidur, M. A. Kalam, M. H. Jayed, M. A. Wazed, Comparative engine performance and emission analysis of CNG and gasoline in a retrofitted car engine, Appl Therm Eng. 30 (2010) 2219-2226.
[5] M. A. Kalam, H. H. Masjuki, An experimental investigation of high performance natural gas engine with direct injection, Energy 36 (2011) 3563-3571.
[6] M. Sarabi, E. Abdi Aghdam, Experimental analysis of in-cylinder combustion characteristics and exhaust gas emissions of gasolinenatural gas dual-fuel combinations in a SI engine, Journal of Thermal Analysis and Calorimetry. http://dx.doi.org/10.1007/s10973-019-08727-2/
[7] R. Behrad, E. Abdi Aghdam, Experimental study of knocking phenomenon in different gasoline-natural gas combinations with gasoline as the predominant fuel in a SI engine, Journal of thermal analysis and calorimetry. http://dx.doi.org/10.1007/s10973-019-08579-w/.
[8] Z. Ran, D. Hariharan, B. Lawler, S. Mamalis, Experimental study of lean spark ignition combustion using gasoline, Ethanol, Natural gas, syngas, Fuel 235 (2019) 530-537.
[9] Asiah Ab. Rahim, N. Rosli Abdullah, Effect of alcohol-gasoline blends (ethanol) on performance and emission of si engine, ARPN Journal of Engineering and Applied Sciences 11 (2016) 416-429.
[10] A. Piknas, P. Saugirdas, G. Juozas Grabys, Influence of composition of gasoline ethanol blends on parameters of internal combustion engines, Journal of KONES Internal Combustion Engines 10 (2003) 3-4 .
[11] [11] Y. Xiumin, G. Zezhou, H. Ling, D. Wei, S. Ping, SH. Weibo, D. Yaodong, H. Fengshuo, Effect of gasoline/n-butanol blends on gaseous and particle emissions from an SI direct injection engine, Fuel 229 (2018) 110.
[12] E. Pipitone, S. Beccari, Performances and emissions improvement of an SI engine fuelled by LPG/gasoline mixtures (No. 2010-01-0615), SAE Technical Paper.
[13] E. Pipitone, S. Beccari, Performances improvement of a S. I. CNG bi-fuel engine by means of double-fuel injection, SAE Technical Paper 24 (2009) 24-58.
[14] MM. Movahed, HB. Tabrizi, M. Mirsalim, Experimental investigation of the concomitant injection ofgasoline and CNG in a turbocharged spark ignition engine, Energy conversion and management http://dx.doi.org/10.1016/j. enconman.2014.01.017/
[15] D. Ramasamy, C. Y. Goh, K. B. Kadirgama, F. Benedict, M. M. Noor, G. Najafi, A. P. Carlucci, Engine performance, exhaust emission and combustion analysis of a 4-stroke spark ignited engine using dual fuel injection, Fuel 207 (2017) 719-728.
[16] S. Di lorio, P. Sementa, B. M. Vaglieco, F. Catapano, An experimental investigation on combustion and engine performance and emissions of a methane-gasoline dual-fuel optical engine (No. 2014-01-1329). SAE Technical Paper.
[17] CH. Gong, L. Zhaohui, CH. Yulin, L. Jiajun, L. Fenghua, H. Yongqiang, Influence of ignition timing on combustion and emissions of a spark-ignition methanol engine with added hydrogen under lean-burn conditions, Fuel http://dx.doi.org/10.1016/ j.fuel.2018.07.097/
[18] S. Di lorio, P. Sementa, B. M. Vaglieco, F. Catapano, An experimental investigation on combustion and engine performance and emissions of a methane-gasoline dual-fuel optical engine (No. 2014-01-1329), SAE Technical Paper.

[19] E. Abdi Aghdam, M. Bashi, Effectiveness of performance characters of a SI engine by varying injection start position of gasoline and natural gas fuels, Modares Mechanical Engineering 15 (2015) 134-142.
[20] M. Ghorbanzadeh, The effect of different fuels (gasoline natural gas) on cyclic variations of a spark ignition engine running on lean mixture, Modares Mechanical Engineering 13 (2013) 101-108.
[21] M. Sarabi, E. Abdi-Aghdam, S. K. Yekani, The Effect Of Burned Residual Gases On Gasoline-NG Dual-Fuel Engine Combustion Performance With Skip-Fire Technique, The Journal of Engine Research 23 (2021) 3-11.
[22] E. Abdi Aghdam, M. Sarabi, M. Khomeyrani, Experimental study of laminar burning velocity for dual fuel (Gasoline-NG)-Air mixture using pressure record in a spherical combustion bomb at higher primary pressure, Fuel and Combustion 11 (2018) 121-134.
[23] F. FAmrouche, P. Erickson, S. Varnhagen, J. W. Park, An experimental analysis of hydrogen enrichment on combustion characteristics of a gasoline Wankel engine at full load and lean burn regime, International Journal of Hydrogen Energy. http://dx.doi.org/10.1016/j.ijhydene.2018.08.110/
[24] X. Duan, L. Yangyang, L. Jingping, G. Genmiao, F. Jianqin, Experimental study the effects of various compression ratios and spark timing on performance and emission of a lean-burn heavy-duty spark ignition engine fueled with methane gas and hydrogen blends, Energy. http://dx.doi.org/10.1016/j.energy.2018.12.029/
[25] E. Abdi Aghdam, M. Ataee Tarzanagh, The Effect of Burned Residual Gases on Optimum Ignition Timing using Skip Fire Technique, JER. 50 (2018) 67-75
[26] MA. Ceviz, AK. Sen, AK. Kuleri, Engine performance, exhaust emissions, and cyclic variations in a lean-burn SI engine fueled by gasolinehydrogen blends, Appl. Therm. Eng. http://dx.doi.org/10.1016/j. applthermaleng.2011.10.039/