Effect of Initial Moisture and Soil Texture on some Characteristics of Puddling Process in Paddy Soils

Subject Areas : Farm water management with the aim of improving irrigation management indicators

Ali Talebpour ¹ , Nader Pirmoradian ² , Mohammad Reza Yazdani ³ , Mohammad Reza Alizadeh ⁴

1 - Former MSc. Candidate, Water Engineering Department, Faculty of Agricultural Sciences, University of Guilan, Rasht, Iran.
2 - Associate Professor, Water Engineering Department, Faculty of Agricultural Sciences, University of Guilan, Rasht, Iran.
3 - Research Assistant Prof., Rice Research Inst. Of Iran, Agricultural Research, Education and Extension Organization (AREEO), Rasht, Iran.
4 - Research Associate Prof., Rice Research Inst. Of Iran, Agricultural Research, Education and Extension Organization (AREEO), Rasht, Iran.

Received: 2023-03-03 Accepted : 2023-05-01 Published : 2023-06-22

Keywords: soil saturation degree, clay percentage, Rice,

Abstract :

Background and Aim: Puddling process is a part of land preparation in rice cultivation. In other words, puddling is an important method of soil management, which is done to disturb the structure of the surface layer of the soil and prepare the field for rice transplanting. Usually, in this process, the soil is flooded and tillage is done on it. The soil texture and the soil moisture conditions before flooding are factors that affect the process of the puddling. Therefore, this study was conducted to determine the effect of initial soil moisture and soil texture on some properties of paddy soils puddling process in Guilan province. Method: The experiment was conducted as a factorial based on a randomized complete block design in three replications. Three textures (silt, silty clay, and clay) of paddy soils were prepared under four initial soil moisture treatments (85, 90, 95, and 100% degrees of saturation). After preparing the soil samples, they were puddled using a laboratory panel. During and after the puddling process, the amount of net water consumed, the depth of water collected on the soil 2 and 6 days after puddling, the soil swelling at the end of the operation, the depth of soil settlement after 2, 4 and 6 days and the final depth of the soil were measured. Statistical analysis of the effect of the experimental treatments on the measured properties and their mean comparison was done with LSD test using SPSS 23 software. Calculations and graphs were done using EXCEL software. Results: The results showed that the independent effects of initial soil moisture and soil texture on all of the measured properties except the depth of soil after 6 days were statistically significant at 1%. With increasing initial soil moisture, the amount of net water consumption and the final depth of soil decreased and other measured parameters increased. On the other hand, the effect of soil texture on net water consumption, water collected on the soil 2 and 6 days after puddling, soil amass at the end of the operation, depth of soil after 2 and 4 days, and the final depth of the soil were statistically significant at 1%. The interaction effect of initial soil moisture and soil texture on soil amass at the end of the operation and final soil depth was statistically significant at 1%, and for the depth of water accumulated on the soil 2 days after puddling and the depth of soil after 2 days was statistically significant at 5%. By increasing the initial soil moisture content from 85 to 100% of saturation degree, the amount of water used for the puddling process decreased by 61%. Conclusion: According to the results, the features of the puddling process are affected by the initial moisture and soil texture. Therefore, the results of this research can be used in the agricultural management of paddy fields in Guilan province. With increasing soil clay content, the measured parameters include the amount of net water consumed, the depth of water collected on the soil 2 and 6 days after puddling, the soil swelling at the end of the operation, the depth of soil settlement after 2, 4 and 6 days and the final depth of the soil were increased. The range of net water consumed in the puddling process for experimental treatments varied between 31 and 114 mm, and the lowest was obtained in silty soil texture with 20% clay and initial moisture treatment of 100% degree of saturation. Estimating water consumption in the puddling process and its correlation with initial soil moisture and clay percentage can inform the management of the agricultural calendar and water allocation program in the Sefidroud irrigation network for paddy fields. This information can help optimize water usage, especially in light of rainfall events at the start of the irrigation season, with the goal of reducing overall water consumption. 

References:

Alizadeh, M. R. (2015). Effect of method and times of puddling on some soil physical properties and rice grain yield. Cereal Research, 5(1), 33-43. https://cr.guilan.ac.ir/article_158_74ae13d443958ffea5e3a89f8961d019.pdf

Arora, V. K. (2006). Application of a rice growth and water balance model in an irrigated semi-arid subtropical environment. Agricultural Water Management, 83(1), 51-57. https://doi.org/https://doi.org/10.1016/j.agwat.2005.09.004

Asenso, E., Wang, Z., Kai, T., Li, J., & Hu, L. (2022). Effects of puddling types and rice establishment methods on soil characteristics and productivity of rice in southern China. Applied and Environmental Soil Science, 2022, 3192003. https://doi.org/10.1155/2022/3192003

Bajpai, R. K., & Tripathi, R. (2000). Evaluation of no-puddling under shallow water tables and alternate tillage methods on soil and crop parameters in a rice–wheat system in Uttar Pradesh. Soil and Tillage Research, 55, 99-106. https://doi.org/10.1016/S0167-1987(00)00111-2

Bameri, A., Lotfi, M., & Khaleghi, M. (2022). The effect of tillage and pudding on some soil physical properties and rice yield in paddy lands (Case study: Ghaemshahr). Applied Soil Research, 10(3), 30-42.

Behera, B. K., Varshney, B. P., & Goel, A. K. (2009). Effect of puddling on puddled soil characteristics and performance of self-propelled transplanter in rice crop. Agricultural Engineering International: CIGR Journal, 10, 1-18.

Buehrer, T. F., & Rose, M. S. (1943). Studies in Soil Structure V. Bound Water in Normal and Puddled Soils. In (Vol. Technical Bulletin, No. 100, pp. 155-218). Agricultural Experiment Station, University of Arizona, Tucson, AZ.

Fallah, V. M. (1969). Rice water requirements and its measurement. S. W. R. Institute. https://civilica.com/doc/1087801/

Fernández-Gálvez, J., & Barahona, E. (2005). Changes in soil water retention due to soil kneading. Agricultural Water Management, 76(1), 53-61. https://doi.org/https://doi.org/10.1016/j.agwat.2005.01.004

Islam, M. J., Mowla, G., Parul, S. S., Alam, M. Z., & Islam, M. S. (2004). Management of cracking puddled soils and its impact on infiltration. Journal of Biological Sciences, 4(1), 21-26.

Jihad-e-Agriculture. (2022). Agricultural Statistics of the Year 2020-21, Volume 1: Agronomy Crops. Deputy for Planning and Economy, Information and Communication Technology Center, Ministry of Jihad-e-Agriculture, Tehran, Iran

Kalita, J., Ahmed, P., & Baruah, N. (2020). Puddling and its effect on soil physical properties and growth of rice and post rice crops: A review. Journal of Pharmacognosy and Phytochemistry, 9(4), 503-510.

Kirchhof, G., Priyono, S., Utomo, W. H., Adisarwanto, T., Dacanay, E. V., & So, H. B. (2000). The effect of soil puddling on the soil physical properties and the growth of rice and post-rice crops. Soil and Tillage Research, 56(1), 37-50. https://doi.org/https://doi.org/10.1016/S0167-1987(00)00121-5

Kukal, S. S., & Aggarwal, G. C. (2002). Percolation losses of water in relation to puddling intensity and depth in a sandy loam rice (Oryza sativa) field. Agricultural Water Management, 57(1), 49-59. https://doi.org/https://doi.org/10.1016/S0378-3774(02)00037-9

Kukal, S. S., & Sidhu, A. S. (2004). Percolation losses of water in relation to pre-puddling tillage and puddling intensity in a puddled sandy loam rice (Oryza sativa L.) field. Soil and Tillage Research, 78(1), 1-8. https://doi.org/https://doi.org/10.1016/j.still.2003.12.010

Mairghany, M., Yahya, A., Adam, N. M., Su, A. S. M., Aimrun, W., Elsoragaby, S. J. S., & Research, T. (2019). Rotary tillage effects on some selected physical properties of fine textured soil in wetland rice cultivation in Malaysia. Soil and Tillage Research, 194, 104318. https://doi.org/doi.org/10.1016/j.still.2019.104318

Manik, S. M. N., Pengilley, G., Dean, G., Field, B., Shabala, S., & Zhou, M. (2019). Soil and crop management practices to minimize the impact of waterlogging on crop productivity [Review]. Frontiers in Plant Science, 10. https://doi.org/10.3389/fpls.2019.00140

Mohanty, M., Painuli, D. K., & Mandal, K. G. (2004). Effect of puddling intensity on temporal variation in soil physical conditions and yield of rice (Oryza sativa L.) in a Vertisol of central India. Soil and Tillage Research, 76(2), 83-94. https://doi.org/https://doi.org/10.1016/j.still.2003.08.006

Mousavi, S. F., Yousefi-Moghadam, S., Mostafazadeh-Fard, B., Hemmat, A., & Yazdani, M. R. (2009). Effect of puddling intensity on physical properties of a silty clay soil under laboratory and field conditions. Paddy and Water Environment, 7(1), 45-54. https://doi.org/10.1007/s10333-008-0148-4

Pirmoradian, N., & Davatgar, N. (2019). Simulating the effects of climatic fluctuations on rice irrigation water requirement using AquaCrop. Agricultural Water Management, 213, 97-106. https://doi.org/https://doi.org/10.1016/j.agwat.2018.10.003

Pirmoradian, N., Kamgar-Haghighi, A. A., & Sepaskhah, A. R. (2005). Lateral seepage, deep percolation, runoff, and the efficiencies of water use and application in irrigation rice in Kooshkak region in Fars province, I.R. of Iran. IRAN AGRICULTURAL RESEARCH, 23-24(1-2), 1-8. https://www.sid.ir/en/journal/ViewPaper.aspx?ID=142641

Rautaray, S. K., Watts, C. W., & Dexter, A. R. (1997). Puddling effects on soil physical parameters. Agricultural Mechanization in Asia, Africa and Latin America, 28, 37-40.

Sharma, P. K., & De Datta, S. K. (1985). Effect of puddling on soil physical properties and processes. In Soil Physics and Rice (pp. 217-234). IRRI.

Sharratt, B., Zhang, M., & Sparrow, S. (2006). Twenty years of tillage research in subarctic Alaska: I. Impact on soil strength, aggregation, roughness, and residue cover. Soil and Tillage Research, 91. https://doi.org/10.1016/j.still.2005.11.006

Siadat, H. (1970). Rice irrigation studies in Rasht water and soil station. S. W. R. Institute. https://civilica.com/doc/1086505/

Singh, K., Gajri, P. R., & Arora, V. (2001). Modelling the effects of soil and water management practices on the water balance and performance of rice. Agricultural Water Management, 49, 77-95. https://doi.org/10.1016/S0378-3774(00)00144-X

Singha, R., Chattopadhyay, S., & Maji, S. (2022). Puddling and its Effect on Soil Physical Condition. Agriculture&Food: E-Newsletter, 4(6), 492-494.

Verma, A. K., & Dewangan, M. L. (2006). Efficiency and energy use in puddling of lowland rice grown on Vertisols in Central India. Soil and Tillage Research, 90(1), 100-107. https://doi.org/https://doi.org/10.1016/j.still.2005.08.009

Verma, V. P. (1996). Water use in relation to soil manipulation for wet land paddy cultivation on clay loam. Journal of Indian Water Resources Society, 62-64.

Yoshida, S., & Adachi, K. (2002). Influences of puddling intensity on the water retention characteristics of clayey paddy soil. Proceedings of the 17th World Congress of Soil Science. 14-21 August 2002, 5, 2351-2359.