Numerical Study of Non-Gray Radiative Heat Transfer in a T-shaped Furnace
محورهای موضوعی : optimization and simulation
Amin Al Taha
1
(Department of Mechanical Engineering,
Kerman Branch, Islamic Azad University, Kerman, Iran)
MohamadMehdi Keshtkar
2
(Department of Mechanical Engineering,
Kerman Branch, Islamic Azad University, Kerman, Iran)
کلید واژه: Radiative Heat Transfer, Blocked-Off, Non-Gray Media, Discrete Ordinate Method, Weighted Sum of Gray Gas Method,
چکیده مقاله :
Radiative heat transfer has an important role in many industrial equipment; i.e. furnaces, boilers and high temperature heat exchangers. In this paper, combination of Weighted Sum of Gray Gas Method (WSSGM) and Discrete Ordinate Method (DOM) are used together in order to numerically study the radiative heat transfer behavior in a non-gray participating medium. Moreover, the concept of Blocked-off region for irregular geometries is used to simulate the T-shaped furnace. The effect of different radiative parameters, i.e. scattering coefficient and wall emissivity on thermal behavior and wall heat fluxes is investigated and compared for both gray and non-gray media. The results show thatwhen scattering coefficient increases, more radiation is scattered in the medium and therefore less heat flux reaches the walls such that by increasing scattering coefficient from 1.0 to 5.0, the incident radiative heat flux decreases up to 15% in some parts of bottom wall. It is seen that by increasing wall emissivity from 0.5 to 1.0, wall heat flux increases more than 60%. Moreover, results show that, by increasing the temperature, the maximum error strongly increases which indicates that in many engineering problems, the gray medium assumption leads to great error in results.
[1] Sakami, M., Charette, A., Application of a Modifed Discrete Ordinates Method to Two-Dimensional Enclosures of Irregular Geometry, Journal of Quantitative Spectroscopy & Radiative Transfer, Vol. 64, 2000, pp. 275-298.
[2] Koo, H. M., Goutière, R. V., Le, V., and Song, T. H., Comparison of Three Discrete Ordinates Methods Applied to Two-Dimensional Curved Geometries, International Journal of Thermal Sciences, Vol. 42, 2003, pp. 343-359.
[3] Talukdar, P., Discrete Transfer Method with The Concept of Blocked-Off Region for Irregular Geometries, Journal of Quantitative Spectroscopy & Radiative Transfer, Vol. 98, 2006, pp. 238-248.
[4] Borjinia, M. N., Guedri, K., and Said, R., Modeling of Radiative Heat Transfer in 3d Complex Boiler with Non-Gray Sooting Media, Journal of Quantitative Spectroscopy & Radiative Transfer, Vol. 105, 2007, pp. 167–179.
[5] Han, S. H., Baek, S. W., and Kim, M. Y., Transient Radiative Heating Characteristics of Slabs in A Walking Beam Type Reheating Furnace, International Journal of Heat and Mass Transfer, Vol. 52, 2009, pp. 1005–1011.
[6] Jang, J. H., Lee, D. F., Kim M. Y., and Kim, H. G., Investigation of the Slab Heating Characteristics in A Reheating Furnace with The Formation and Growth of Scale On the Slab Surface, International Journal of Heat and Mass Transfer, Vol. 53, 2010, pp. 4326–4332.
[7] Keshtkar, M. M., Gandjalikhan Nassab, S. A., Theoretical Analysis of Porous Radiant Burners Under 2-D Radiation Field Using Discrete Ordinates Method, Journal of Quantitative Spectroscopy & Radiative Transfer, Vol. 110, 2009, pp. 1894-1907.
[8] Ansari, A. B., Gandjalikhan Nassab, S. A., Study of Laminar Forced Convection of Radiating Gas Over an Inclined Backward Facing Step Under Bleeding Condition Using the Blocked-Off Method, ASME, Journal of Heat Transfer, Vol. 133, 2011, pp. 72-83.
[9] Abbassi, M. A., Guedri, K., Borjini, M. N. Halouani, K., and Zeghmati, B., Modeling of Radiative Heat Transfer in 2D Complex Heat Recuperator of Biomass Pyrolysis Furnace: A Study of Baffles Shadow and Soot Volume Fraction Effects, International Journal of Physical, Nuclear Science and Engineering, Vol. 8, No. 2, 2014, pp. 119-129.
[10] Payan, S., Hosseini Sarvari, S. M., and Behzadmehr, A., Inverse Boundary Design Radiation Problem Within Combustion Enclosures with Absorbing-Emitting Non-Gray Media, Numerical Heat Transfer, Part A: Applications, Vol. 65, 2014, pp. 1114–1137.
[11] Payan, S., Farahmand, A., and Hosseini Sarvari, S. M., Inverse Boundary Design Radiation Problem with Radiative Equilibrium in Combustion Enclosures with PSO Algorithm, International Communications in Heat and Mass Transfer, Vol. 68, 2015, pp.150–157.
[12] Zeyghami, M., Rahman, M. M., Analysis of Combined Natural Convection and Radiation Heat Transfer Using a Similarity Solution, Energy Research Journal, Vol. 6, No. 2, 2015, pp. 64- 73.
[13] Nenad, D. J., Srdjan, V., Ivan, D., and Aleksandar, R., Monte Carlo Simulation for Radiative Transfer in a High-Pressure Industrial Gas Turbine Combustion Chamber, Journal of Thermal Science, Vol. 20, 2016, pp. 197- 206.
[14] Chishty, M. A., Bolla, M., Hawkes, E., Pei, Y., and Kook, S., Assessing the Importance of Radiative Heat Transfer for ECN Spray a Using the Transported PDF Method, International Journal of Fuels and Lubricants, Vol. 9, No. 1, 2016, pp. 100-107.
[15] Wang, C., Geb, W., and He, B., A Full-Spectrum K-Distribution Look-Up Table for Radiative Transfer in Nonhomogeneous Gaseous Media, Journal of Quantitative Spectroscopy and Radiative Transfer, Vol. 168, 2016, pp. 46-56.
[16] Keshtkar, M. M., Amiri, B., Numerical Simulation of Radiative-Conductive Heat Transfer in an Enclosure with an Isotherm Obstacle, Heat Transfer Engineering, Vol. 39, No.1, 2018, pp. 72–83.
[17] Ren, T., Modest, M. F., and Roy, S., Influence of the Gray Gases Number in the Weighted Sum of Gray Gases Model on the Radiative Heat Exchange Calculation Inside Pulverized Coal-Fired Furnaces, J. Eng. Gas Turbines Power, Vol. 140, No. 5, 2018, pp. 97- 108.
[18] Yang, X., Clements, A., Szuhánszki, J., Huang, X., Farias O., Lia, J., Gibbins, J., Liu, Z., Zheng, C., Ingham, D., and Ma, L., Prediction of the Radiative Heat Transfer in Small and Large Scale Oxy-Coal Furnaces, Applied Energy journal, Vol. 211, 2018, pp. 523- 537.
[19] Ge, L., Gong, K., Cang, Y., Luo, Y., Shi, X., and Wu, Y., Magnetically Tunable Multiband Near-Field Radiative Heat Transfer Between Two Graphene Sheets, Phys. Rev., Vol. 2, 2019, pp. 23- 37.
[20] Shiue, R., Gao, Y., Tan, C., Peng, C., Zheng, J., Efetov, D., Kim, Y., Hone J., and Englund, D., Thermal Radiation Control from Hot Graphene Electrons Coupled to A Photonic Crystal Nanocavity, Nature Communications, Vol. 10, 2019, pp. 45- 56.
[21] Yin, C., Rosendahl, L. A., New Weighted Sum of Gray Gases Model Applicable to Computational Fluid Dynamics (CFD) Modeling of Oxy−Fuel Combustion: Derivation, Validation, and Implementation, Energy Fuels, Vol. 24, No. 10, 2010, pp. 6275-6282.
[22] Henrion, L., Gross, M. C., Fernandez, S. F., Paul, C., Kazmouz, S., Sick V., and Haworth, D. C., Characterization of Radiative Heat Transfer in A Spark-Ignition Engine Through High-Speed Experiments and Simulations, Oil & Gas Science and Technology, Vol. 74, No. 1, 2019, pp. 61-73.
[23] Dombrovsky, A., Dembelea, S., Wend, J. X., and Sikic, I., Two-Step Method for Radiative Transfer Calculations in A Developing Pool Fire at The Initial Stage of Its Suppression by A Water Spray Leonid, International Journal of Heat and Mass Transfer, Vol. 127, Part B, 2018, pp. 717-726.
[24] Atashafrooz, M., Gandjalikhan Nassab, R., Lari, K., Numerical Analysis of Interaction Between Non-Gray Radiation and Forced Convection Flow Over a Recess Using the Full-Spectrum K-Distribution Method, Heat and Mass Transfer, Vol. 52, No. 2, 2015, pp. 717-726.
[25] Fathi, M., Hosseini, R., and Rahmani, M., Calculations of Non-Gray Gas Radiative Heat Transfer by Coupling the Discrete Ordinates Method with The Leckner Model in 3d Rectangular Enclosures, Heat and Mass Transfer, Vol. 52, No. 11, 2015, pp. 1-9.
[26] Chu, H., Ren, F., and Zheng, S., A Comprehensive Evaluation of the Non Gray Gas Thermal Radiation Using the Line-By-Line Model in One- And Two-Dimensional Enclosures, Applied Thermal Engineering, Vol. 124, 2017, pp. 74-86.
[27] Boutoub, A., Benticha, H., Non-Gray Radiation Analysis in Participating Media with the Finite Volume Method, Turkish Journal of Engineering and Environmental Sciences, Vol. 30, No. 3, 2006, pp. 183-194.
[28] Jozaalizadeh, T., Toghraie, D., Numerical Investigation Behavior of Reacting Flow for Flameless Oxidation Technology of Mild Combustion: Effect of Fluctuating Temperature of Inlet Co-Flow, Energy, Vol. 178, No. 3, 2019, pp. 530-537.
[29] Golestaneh, S. M., Toghraie, D., Separation of Particles from The Gas by Using of Cyclonic Separation in The Cyclotubes of Scrubber Installed in Gas Compressor Station, Powder Technology, Vol. 343, 2019, pp. 392-421.
[30] Dabiri, S., Khodabandeh, E., Poorfar, Khoeini A., Mashayekhi, R., Toghraie, D., and Abadian Zade, A., Parametric Investigation of Thermal Characteristic in Trapezoidal Cavity Receiver for A Linear Fresnel Solar Collector Concentrator, Energy, Vol. 153, 2018, pp. 17-26.
[31] Hemmat Esfe, M., Hajmohammad, H., Toghraie, D., Rostamian, H., Mahian O., and Wongwises, S., Multi-Objective Optimization of Nanofluid Flow in Double Tube Heat Exchangers for Applications in Energy Systems, Energy, Vol. 137, 2017, pp. 160-171.
[32] Naderi, M., Ahmadi, G., Zarringhalam, M., Akbari, O., and Khalili, E., Application of Water Reheating System for Waste Heat Recovery in Ng Pressure Reduction Stations, with Experimental Verification, Energy, Vol. 162, 2018, pp. 1183-1192.
[33] Ahmadi, G., Toghraie, D., and Akbari, O., Energy, Exergy and Environmental (3e) Analysis of The Existing Chp System in A Petrochemical Plant, Renewable and Sustainable Energy Reviews, Vol. 99, 2019, pp. 234-242.
[34] Ahmadi, G., Toghraie, D., and Akbari, O. A., Technical and Environmental Analysis of Repowering the Existing Chp System in A Petrochemical Plant: A Case Study, Energy, Vol. 159, No. 3, 2018, pp. 937-949.
[35] Modest, M. F., Radiative Heat Transfer, Second ed. 2003: Academic Press, 2003.
[36] Smith, T. F., Shen, Z. F., and Friedman, J. N., Evaluation of Coefficients for The Weighted Sum of Gray Gases Model, ASME Journal of Heat Transfer, Vol. 104, 1982, pp. 602-608.
[37] Fiveland, W. A., Discrete-Ordinates Solutions of the Radiativetransport Equation for Rectangular Enclosures, ASME, Journal of Heat Transfer, Vol. 106, 1984, pp. 699-706.
[38] Goutierea, V., Liub, F., and Charette, A., An Assessment of Real-Gas Modelling in 2d Enclosures, Journal of Quantitative Spectroscopy & Radiative Transfer, Vol. 64, 2000, pp. 299-326.
